Millipore Simplicity User Manual

Page 1/36Page 1/36Page 1/36Operating andMaintenance ManualSimplicity™Water Purification SystemMILLIPOREOperating andMaintenance ManualSimplicity™Water

Page 10/36Page 10/36Page 10/36INTRODUCTION _________________________________________Dimensions and weightHeight 460 mm (18.11 inches)Length 248 mm (9.

Page 11/36Page 11/36Page 11/36Unpacking ______________________________________________After unpacking the shipping container you should find (Figure 2

Page 12/36Page 12/36Page 12/36Filling the Integral Reservoir _______________________________Figure 31. Raise the reservoir-locking handle to vertical

Page 13/36Page 13/36Page 13/36___________________________________________INSTALLATIONElectrical connection ______________________________________The e

Page 14/36Page 14/36Page 14/36Purging the Pak __________________________________________1. Install the connector (Figure 2,C) into the POU valve.Note:

Page 15/36Page 15/36Page 15/36The simplicity system should be used in the manner specified by this user’s manual, otherwise theprotection provided by

Page 16/36Page 16/36Page 16/36These different modes are displayed on the screen, and are described below:OPERATING STATUS OF SYSTEMMODE DISPLAYSTANDBY

Page 17/36Page 17/36Page 17/36The keypad allows the user to activate the different operatingmodes and to review information about consumables lifetime

Page 18/36Page 18/36Page 18/36Consumable lifetime ______________________________________KEYPAD ACTION DISPLAYPAK LIFETIMEIn either OPERATE or STANDBY

Page 19/36Page 19/36Page 19/36Choosing the non-temperature compensated resistivity display __KEYPAD ACTION DISPLAYIn either OPERATE or STANDBY mode,pr

Page 2/36Page 2/36Page 2/36NOTICE ___________________________________________Information in this document is subject to change without notice and shou

Page 20/36Page 20/36Page 20/36Selecting the unit of measure ______________________________KEYPAD ACTION DISPLAYIn either OPERATE or STANDBY modePress

Page 21/36Page 21/36Page 21/36Setting the displayed language_____________________________KEYPAD ACTION DISPLAYIn either OPERATE or STANDBY modePress M

Page 22/36Page 22/36Page 22/36Replacing the consumables ________________________________1. Put the Simplicity into STANDBY mode by pressing the OPERAT

Page 23/36Page 23/36Page 23/3618. Press the OPERATE button to go from STANDBY to OPERATE mode19. Open the POU valve and draw around 0.5 litre of water

Page 24/36Page 24/36Page 24/36WARNING: Verify that there is no electrical power going to the Pack at this time.Accidental exposure to Ultraviolet ligh

Page 25/36Page 25/36Page 25/36Shutting down the system for an extended period of time ______Keep the Simplicity in STANDBY mode when water is not need

Page 26/36Page 26/36Page 26/36TROUBLESHOOTING______________________________________Troubleshooting table _____________________________________Whenever

Page 27/36Page 27/36Page 27/36_____________________________________ TROUBLESHOOTINGSTATUS / PROBLEM CAUSE REMEDYEXCHANGE PACK. The operational lifetim

Page 28/36Page 28/36Page 28/36SystemsSimplicity Water Purification System, 230 V 50 Hz SIMS50000Simplicity Water Purification System, 115 V 60 Hz SIMS

Page 29/36Page 29/36Page 29/36Millipore’s Standard Warranty _____________________________Millipore Corporation (“Millipore”) warrants the products wil

Page 3/36Page 3/36Page 3/36___________________________ DECLARATION OF CONFORMITYDECLARATION OF CONFORMITYEUROPEAN UNION EC DIRECTIVESDirective 89/336/

Page 30/36Page 30/36Page 30/36Figure 1The water flow schematic of the Simplicity is shown below. Only the main components are shown.Reservoir 1Pump 2*

Page 31/36Page 31/36Page 31/36__________________________________________ ILLUSTRATIONSFigure 2MANUALMILLIPOREMILLIPOREABCEFD__________________________

Page 32/36Page 32/36Page 32/36Figure 3ILLUSTRATIONS __________________________________________ABDCFigure 3ILLUSTRATIONS ______________________________

Page 33/36Page 33/36Page 33/36Figure 4__________________________________________ ILLUSTRATIONSABCEDFigure 4__________________________________________

Page 34/36Page 34/36Page 34/36Figure 5ILLUSTRATIONS __________________________________________ABFigure 5ILLUSTRATIONS ________________________________

Page 35/36Page 35/36Page 35/36Figure 6__________________________________________ ILLUSTRATIONSABFigure 6__________________________________________ ILL

Page 36/36Page 36/36Page 36/36To Place an Order or Receive Technical AssistanceFor additional information call the nearest number listed below:In the

Page 4/36Page 4/36Page 4/36GETTING STARTEDHOW TO USE THIS MANUAL ... 6Warnings ...

Page 5/36Page 5/36Page 5/36MORE ABOUT SIMPLICITYUSE OF THE KEYPAD ... 17Standard

Page 6/36Page 6/36Page 6/36This manual describes how to install, maintain and use the Simplicity.It is recommended that this document is completely re

Page 7/36Page 7/36Page 7/36General Information ______________________________________Simplicity is a water purificationsystem fed through an integrate

Page 8/36Page 8/36Page 8/36System performancePurified water qualitySimplicity Simplicity 185Resistivity 18.2 MΩ-cm at 25 °C 18.2 MΩ-cm at 25 °CTOC* 1

Page 9/36Page 9/36Page 9/36_________________________________________ INTRODUCTIONEnvironmental SpecificationsStorage temperature -40°C to 70°C at 5% t